Currently reading: Audi plots new petrol-electric hybrid powertrain for 2017
New electric motor tech paves the way for advanced petrol hybrid powertrain solutions

Audi is betting on the electrification of its future cars to improve real-world economy and reduce exhaust pollution, company bosses have told Autocar.

The move will also allow the company to usher in some highly advanced suspension innovations as well as providing a degree of autonomy that goes beyond simple driving assistance.

This shift towards ‘mild hybrid’ systems and more conventional plug-in hybrids should also result in Audi’s future line-up moving away from diesel engines, particularly across the company’s smaller models, including the Audi A1, Audi A3 and Audi A4.

Moving to petrol hybrid engines will also allow Audi to exploit its new ‘predictive efficiency assistant’ technology, which uses mapping information and live traffic reports to automatically switch between power sources, as well as taking advantage of downhill stretches of road to ‘coast’ the engine.

The key to Audi’s move is the adoption of Integrated Starter Generators (ISG). These are large electric motors that act as the starter motor and alternator but can also assist the engine by sending torque through the drive belt to the engine’s crankshaft. The system is also fitted with a small lithium ion battery.

Audi has developed an ISG that works on an ordinary 12V electrical system, so it could be fitted to today’s A1 and A3 models. The company says the system allows the stop-start system to cut in below 9mph and also allows the engine to coast at high speeds, both significant fuel saving measures. The first production version is expected in 2017.

Today’s A3 1.4 TSI Ultra has a claimed economy figure of 60mpg, but the 12V ISG system would push that up to 65mpg. However, the combination of coasting and energy recuperation under braking could see the real-world economy of the ISG-equipped engine rise even higher than the lab figures suggest.

Audi is also planning to introduce a more powerful 48V ISG system, the first of which will be revealed before the end of the year, using a combined 12V and 48V set-up.

The 48V system allows for a much more powerful ISG (up from 1.5bhp to 16bhp) and periods of engine coasting of up to 30 seconds.

However, the introduction of full-scale 48V electronics into future models from 2017 will also allow Audi to introduce electrically driven engine compressors, which will come in two forms. Firstly, otherwise conventional turbochargers that are spun up by an electric motor will be able to provide boost even at very low crankshaft speeds.

The second type, as already seen on the RS5 Competition concept, is a separate electric compressor motor that forces air into the turbochargers at low engine speeds but can also eliminate turbo lag during higher-speed driving.

Back to top

This 48V electrical system has also allowed Audi to develop three new suspension concepts, which capitalise on the fact that the 48V system provides as much as four times as much power as a 12V set-up.

First to arrive will be an active anti-roll bar system that uses planetary gears driven by small electric motors to couple and uncouple the roll bars individually from the chassis.

Uncoupled, the anti-roll bars will allow a more comfortable ride, but when active, Audi claims reduced understeer, less roll in corners and increased lateral acceleration. However, the anti-roll bars’ twisting when locked allows the small electric motors to act as generators and create enough charge on a “moderate bumpy road” to power the whole system.

Further away from production are the eROT electromechanical dampers. These compact, barrel-shaped dampers are about 10cm across and 15cm deep and are intended to replace conventional upright hydraulic dampers. They are connected to a lever arm which, through a series of gears, feeds the forces into an electric motor.

Not only do the eROT units save a great deal of space, but the rebound and compression damping rates can also be set in very fine increments independently of each other. The agitation of the dampers creates an electrical charge, and the rougher the road, the greater the amount of electricity generated.

Audi claims that these dampers could reduce a car’s average CO2 emissions by as much as 3g/km.

Audi's autonomous powertrain tech

Audi’s drive towards hybrids and electrification is part of a big move towards autonomous powertrain management. ‘Predictive efficiency assistant’ is being launched on the Q7 e-tron, due in the UK next March.

The system uses 3D information from the satellite navigation and live traffic information, which it picks up over the internet. Once the driver has entered the chosen destination in the sat-nav, the new software takes over control of the hybrid powertrain.

It calculates when to use the internal combustion engine, when to deploy both the engine and electric motor, when to run on the battery alone and when the battery charge needs to be preserved for use later in the journey. It even advises the driver when to coast in order to save fuel.

Audi’s engineers believe that this autonomous control of the hybrid powertrain will maximise economy and allow future models to drive through towns and villages in zero-emissions mode. Real-world fuel economy should also be markedly improved.

Join the debate

Comments
7
Add a comment…
TS7 26 November 2015

The more they overthink the plumbing...

...the easier it is to stop up the drain. One worries about the increasing complexity of ALL modern cars: "active anti-roll bar system that uses planetary gears driven by small electric motors to couple and uncouple the roll bars individually from the chassis". We can't all afford to get a new car every 3 years - some of us need to keep a car going a little longer, and I pity the poor person who'll end up getting one of these from a out of town used car dealership ten years down the line.
LP in Brighton 26 November 2015

Big headline for a small story

How mild must a "mild" hybrid be to qualify for the name? This one appears to be to be so mild that the electric assist will make very little difference in real world cut and thrust driving - it's really only there to cheat the test cycle. Audi's system is decades behind what Toyota is currently offering with its powerful motor and energy recovery, high efficiency Atkinson cycle petrol engine and integrated CVT transmission. Not only is the Japanese hybrid quantifiably better, it's very well proven and available right now. It's the system I'd chose.
winniethewoo 26 November 2015

What kind of difference can a

What kind of difference can a 1.5bhp boost make? I can see how a 16bhp electric assistance can make a difference. I would be quite keen to have this sort of system in my next car if it makes a significant difference to urban MPG. II generally do short trips in town and spend most of my time stuck in traffic but also do a big day trip once or twice a month.
Clarkey 26 November 2015

winniethewoo wrote: What kind

winniethewoo wrote:

What kind of difference can a 1.5bhp boost make? I can see how a 16bhp electric assistance can make a difference. I would be quite keen to have this sort of system in my next car if it makes a significant difference to urban MPG. II generally do short trips in town and spend most of my time stuck in traffic but also do a big day trip once or twice a month.

This is what I am interested to find out. The Suzuki system can provide about 3bhp of boost, adding about 50Nm of torque up to 3900rpm. I can see how this might help out with low-end driveability on a small, naturally aspirated, petrol engine like the Dualjet 1.2. I imagine it might be like the gen 1 Honda Insight and Civic IMA where the only real manifestation of the system was an ability to be in a gear higher than normal?

Adrian987 26 November 2015

Hybrid bike

If you could downgrade to an electric-assist bicycle for urban work, @winniethewoo, you could have the effect of this engine tech today, not get so snarled up in traffic, and keep the car for the longer trips! There's a chappie on such a bike I see most mornings, going along at a fair lick, overtaking all the other cyclists....

Not sure how the "free-wheeling" will feel in the Audi, but it can be an acquired taste, based on my experience of it on my dsg car. I remain to be convinced over the fuel saving benefits, my thinking is that the skilled driver can do more to save fuel than the tech.